1、Baolong Electronic Group .TBaolong Electronic Group .TREFNo.PRODUCTPRODUCTBLT-CUSTOMERAPPROVEL/Item/名稱: 3.2mmVibration M/型號Date/日期Item/名稱: 3.2mmVibration M/型號Date/日期.中國寶龍電子地址：中國浙江省樂清東路寶龍工業園PRODUCT SPECIFICATIONS/產品規PRODUCT PRODUCT SPECIFICATIONS/產品規PRODUCT CoList、Register For Storage al crc 5 8、11.

2、Lot no. indication/標12.Reflowspecification/回流老化曲 REASONFORCONTENTFOR/CustomerAdd“Vibrationswing”Validity of ie confirm according as the best newest ie of the register， except for speexplain./ 版本有效性以更改Date/福CHINA BAOLONG ELECTRONIC GROUP 中國寶龍電子PRODUCT SPECIFICATIONS/產品規格PRODUCT Applications/用途This sp

3、ecification is app s to BLT-4311vibration motor to be used for cellular phone and other handy communication tools. Manufactured by CHINA BAOLONG ELECTRONIC GROUP CO., . /本規格書適用于 BLT-4311 型振動電機，該電機由寶龍電子制造，主要用于移動 PRODUCT SPECIFICATIONS/產品規格PRODUCT Applications/用途This specification is app s to BLT-4311

4、vibration motor to be used for cellular phone and other handy communication tools. Manufactured by CHINA BAOLONG ELECTRONIC GROUP CO., . /本規格書適用于 BLT-4311 型振動電機，該電機由寶龍電子制造，主要用于移動 及其它便 Measure at normal temperature and humidity, Should any doubt arise in judgment, test shall be conducted at the follo

5、wing conditions /如無特殊說明測試一般在常溫、常濕下進行，為了保證 的一性，測試應在下表Storage Environment/ No./Items/項 Specification/Storage-40 5% No./Items/項 Specification/ Shafthorizontal/使電機軸向處于水平No./Items/項 Contents/說 3.2DCcored Numberofmagnetpoles/2-poles(Innermagnet(外置磁極型式 PreciousbrushandPRODUCT SPECIFICATIONS/產品規PAGE/頁碼5 /PR

6、ODUCT No./Items/項 Ratednominal operating/工作電壓 Operatingvoltage(m2.7 V DC 2.33.2VDCRatedMeasureatratedvoltageandratedload/在額定電壓和75mAPRODUCT SPECIFICATIONS/產品規PAGE/頁碼5 /PRODUCT No./Items/項 Ratednominal operating/工作電壓 Operatingvoltage(m2.7 V DC 2.33.2VDCRatedMeasureatratedvoltageandratedload/在額定電壓和75mA

7、RatedMeasureatratedvoltageandratedload/在額定電壓和 At rated load( counterweight) anyition of rotor(counter weight to be turned slowly at 360). /在2.3V Measure currenlocked counter weight ( R1.72.8) in rated voltage(2/3R R:1 extreme resisting rate,Notition when the brushes contact the commu or at the two c

8、ontact po s)/在90mA Measure(336) Supply wiC 110V betn a lead wire and motor caseduring1minute/在電機的機殼和接觸腳間施加交流電 110V，歷時 1 分鐘。1mAMax /絕緣電AtDC100Vntheleadwiresand 10MWeight（Underratedvoltageand35ms50%strength,65ms100strength/35ms No./Items/項 Specification/Appearance/Visual/Noscarruststainanddent/無s/Usev

9、erniercaliperandmicrometerMass/ ShaftpullPullshallbedalongwith5kgf(49N)ShaftendDistanceofaxialplayonshaft/軸沿著軸向移MechanicalMeasured at rated voltage and rated （counterweight ）,the distance along with shaft directer is 10cm bet n microphone and motor./額輪 PRODUCT SPECIFICATIONS/產品規PRODUCT According to

10、demand in following table test alone in every item,then measuring itemable 6 , changing rateofmeasureddatemustbewithin 35ofinitialPRODUCT SPECIFICATIONS/產品規PRODUCT According to demand in following table test alone in every item,then measuring itemable 6 , changing rateofmeasureddatemustbewithin 35of

11、initialvalue./按下列項目分組進行試驗后，按6.2、6.3項性No./Items/項 High temperature storage 96hrs at 80,then recovery 4hr at normal temperature./80964 小test 48hrs at 40 ,90%HR,then recovery 4hr atnormal temperature ./溫度40，濕度 90%的環境下放置 48 小時，然后常4Low temperature storage 96hrs at -40,then recovery 4hr at temperature溫度-4

12、0964小HeatcycleConfirmed to operating of motor during 1 cycles as following test condition (without presence of water droplets on the motor), then return to normal temperature and humidity for 4 cyc efore test/確保電機在室溫下恢復 4 小時后，進 試。 Motor shall be app d with following method at standard packing condit

13、ion. /電機在標準的包裝條件下，按以下要求進行試驗： 1.Vibration frequency range/振頻范圍: 1055Hzp ratio/振頻變化: 105510 Hz approximate 1min/約1 分鐘 4.Method of changing the sp vibration frequency/變頻方法: Logarithmic or linear/對數或線形變化Direction of vibration/振動方向: Three pendicular directions including actuator/包括動作機構在內的三個垂直方向 DropSet t

14、hemotor on the heavy block about 60g weight（include the motor） 重的物體上 落下到水泥地板上。Times/次數：Threedropsp laneforatotalof18drops/318SaltsprayEx ure the motor to an environment with 35,5%NaCl resolution spray for 24 hours.Visual examination identify no signs of corro ./將電機放置于鹽霧試驗箱，試驗箱內溫度 35，鹽溶液濃度 51%；PH值為 6

15、.57.2；鹽霧沉降量12ml/80cm2.h；濃度5%的中性鹽溶24 小時。持續期滿， 試驗樣品表面，用干凈的棉布擦拭后LowtemperatureureLifetest/低溫性Toain(A)cycleunderhightemperatureforLowtemperatureureLifetest/低溫性Toain(A)cycleunderhightemperatureforPRODUCT SPECIFICATIONS/產品規PRODUCT 8.Life HightemperatureureLifetest/高溫性（C）Toain(A)cycleunderhightemperaturefo

16、r （B）Toain(A)cycleforhesoftemperature Life test conditions: Test voltage/DC2.7V shall bed reciprocally repeating on: 2.5sec ，off:2.5secwithratedloadatnormaltemperatureandhumidity/在常溫常濕下按2.5秒開、 1On/Off/ ure ure- /、Againstinitialratewhenstandardno.ofionisn+30%/-20%、Againstinitialratewhenstandardcurren

17、trateisn+20%/-PRODUCT SPECIFICATIONS/產品規PAGE/頁碼8/PRODUCT Remarks/注意事 No./Items/項 Whatever item not shisspecificationwillnotbeguaranteed.未在本規格中Current terminals should not be twisted or bent moren twice./接電端子彎次數不可多于 2 次。The portion when lead wire and terminal are soldered should not be under Donotsub

18、jectthemotorunderlockedconditionforlonghours在馬達通電時，不Do not exert prerebypushingthePRODUCT SPECIFICATIONS/產品規PAGE/頁碼8/PRODUCT Remarks/注意事 No./Items/項 Whatever item not shisspecificationwillnotbeguaranteed.未在本規格中Current terminals should not be twisted or bent moren twice./接電端子彎次數不可多于 2 次。The portion w

19、hen lead wire and terminal are soldered should not be under Donotsubjectthemotorunderlockedconditionforlonghours在馬達通電時，不Do not exert prerebypushingthecurrentterminalstowardsthedirectionofthe ernal motor. /不可向馬達一側強行擠壓接電端子。Out-goingtestdataandCpkdatawillbeattached(n-35)for Loaded roion r.p.m.Loadedcur

20、rent Lockcurrent(Startingcurrent)StartingvoltageV(withouttheconsiderationofCpkvalue)負載電流：m PRODUCT SPECIFICATIONS/產品規 1reelpacking uble wall corrugated carboard(ernaldimen1000pcs/1 reel 6 reel =6000pcs11.Lotno.indication/The lot no. is indicated by prasbelow:/機身噴碼所表含義 :AZ/ :1V/ )/ :2011-1/ Baolong-B/ 123456789123456789ABCDEFGHIJKLMNOPQRSTUVPRODUCT SPECIFICATIONS/產品規 1reelpacking uble wall corrugated carboard(ernaldimen1000pcs/1 reel 6 reel =6000pcs11.Lotno.indication/The lot no. is indicated by prasbelow:/機身噴碼所表含義 :AZ/ :1V/ )/ :2011-1/ Baolong-B/ 123456789123456789ABCD